Tuesday, March 28, 2017

2017 REVISED (w/Links!) - How to Go From Winter's Slumber to Spring's Re-Awakening And Perform A Yearly Safety Check.

Usually, I wait until I can de-winterize my RV but the weather has had other ideas.. Think of this article as more of a "wishful thinking" piece for me and a really useful list for you!


Look Ma...No Snow!

    Time to wake the slumbering beast (well my RV is more like a tame housecat than a beast.) I am going to de-winterize, inspect and repair for the upcoming season. Winter was great for planning and researching projects, not so great for actually DOING them! If you plan ahead and prepare, getting your RV ready for the season or checking it once a year if you are blessed to live in a warmer climate, should go smoothly and easily. Yes, I know NOTHING ever goes, smoothly and easily. Let's hope this Spring's charmed.

**Many of the tasks below have links to articles on that subject. Click and find out more!

Start with a list of basic tasks. The list below can be changed to suit your particular RV, but is a good guideline. Mine reads as follows:

OUTSIDE
Remove Cover Straps (guess who forgot to undo the straps AGAIN last year!)
Remove Cover
Inspect Cover for Rips and Tears, Repair if Needed/Possible
Roll and Fold Cover and Store. (In a Dry Place!)
Walk Around Outside Look For Obvious Defects
Inspect/Clean Windshield Wiper Blades - Replace If Needed
Inspect Windshield Washer Nozzle and Hoses (Cracks, Breaks, Dry Rot.)
Inspect/Repair Running Lights
Inspect Front/Rear Lights/Headlights
Inspect Mirrors!
Inspect Backup Camera
Inspect Underneath For Leaks, Puddles, Dry Rotted Hoses, Excessive Rust, Cracked Gas Pipe Joints, Frame Problems, etc.
Inspect Tires and Inflate to proper pressure (Check Dates!)
Check TPMS Sensors (Tightness and Battery Replacement, if needed)
Wash RV and Inspect for cracks, chips, glass breaks, leaks, etc. Repair if needed.
Check For Mold/Mildew on Exterior Seals (Clean As Needed)
Open Outside Engine Compartment, Check for Leaks and Nests.
Open Storage Compartments and Inspect Doors, Seals, & Locks(leaks, bugs, critters, etc.)
Clean Outside Refrigerator Compartment (Spiderwebs, Leaves, Nests, etc.)
Clean Outside Furnace Compartment (Spiderwebs, Leaves, Nests, etc.)
Clean Outside Water Heater Compartment (Spiderwebs, Leaves, Nests, etc.)
Replace Water Heater Drain Plug and/or Anode.
Clean Battery(ies) and Terminals if Needed. (Chassis, House and Generator)
Check Coach and Chassis Battery Water Level, Refill if needed. (Distilled Water ONLY!)
Check Hitch Receiver
Check Hitch/Trailer Wiring

INSIDE
Open Door(s) Test Operation. Lubricate if Needed.
Test Operation of Electric Stairs (Lubricate/Repair as Needed)
Turn On Lights, Replace Any Bad Bulbs/Fluorescents
Check All LED Bulbs and Fixtures
Open Vents, Test Seals and Operation
Clean Pop-Locks On Vents
Open Blinds - Check Function (Adjust If Needed), Clean
Open Windows, Test Seals and Operation. Check Locking Mechanisms
Close and Clean Blinds
Open Cabinets (Upper and Lower) Organize Shifted Contents
Check for Leaks; Roof, Doors, Vents, etc.
Check for Critters. (Bugs, Mammals, Gremlins, etc.)
Check & Clean Interior (Carpets, Walls, Floors, Cabinets, Fridge, etc.)
Check LP/Propane/CO Detector Operation
Check Smoke Detector Battery and Operation
Check Monitor Panel, Tanks and Propane
Check Converter/Charger For 12 Volt Output
Check All Fuses and Breakers (12V and 120V)
Confirm Solar Charging System Voltage and Amperage (If Applicable)
Check Bathroom Skylight for leaks and cracks.
Check Bathroom Vent for Operation and Seal.
Check All Flashlights (Batteries, Charged? and Bulbs)
Check and Tighten ALL screws and fasteners Everywhere!

MECHANICAL
Check Oil Level, Fill if Needed
Check Coolant Level, Fill if Needed
Check Brake Fluid Level, Fill if Needed
Check Power Steering Fluid Level, Fill if Needed
Check Transmission Fluid Level, Fill if Needed
Check Windshield Wiper Blades Replace If Needed.
Check Windshield Washer Nozzles, Replace if Needed
Check Windshield Fluid Level, Fill if Needed
Check All Hoses and Tighten Clamps
Check Airbag Compressor for operation and leaks.
Check Air Bag System Pressure
Check Air bag System for Leaks

START-UP CHECKLIST
Check Fuel Levels
Check Battery Volts
Start Engine
Check for Oil Pressure Rise
Listen to Idle (Sound OK?)
Check Idle Speed RPM
Check for Battery Charging (Volts/Amps)
Check TPMS Monitor for Operation and Correct Pressures
Check Temperature Gauge for Rise
Listen for "strange" noises. Clangs, Bonks, Whistles, Squeals, Chattering, Rattles, Clunks etc.
Shift Into Each Gear (Foot on Brake!!)
When In Reverse, Check Backup Camera Monitor
Switch On Dash Air Conditioner (Got Cold Air?)
Select Dash Heat and Defrost (Got Hot Air?)
Shutdown After Everything Warms Up to Operating Temperature
Re-Check Oil Level, Fill if Needed
Re-Check Transmission Fluid Level, Fill if Needed
Go Outside, Look Under RV..Any New Leaks?

GENERATOR/AC POWER CHECKLIST
Check Shore Power Cord & Plugs
Unplug Shore Power Cord
Check Generator Compartment for Oil Leaks
Check generator and Wiring for Obvious Problems
Check Oil Level, Fill if Needed (Coolant too! If you have it)
Start Generator
Check for leaks
Check for Transfer Switch Operation
Run for 30 minutes (or so)
Check Voltage at Sockets without Load
Check Voltage at Sockets with Load
Shutdown Generator
Turn On Inverter (If You Have One!)
Check AC Power From Inverter

PROPANE SYSTEM
Turn On Gas at Main Tank Valve
Listen and Check for Leaks (Use handheld detector)
Check for leaks in Refrigerator, Furnace and Water heater Compartments
Check for leaks Inside (Stove, Water Heater, Furnace, Refrigerator)
Check & Clean Stove Vent System
Light 1 Burner, Check for Blue Flame and Even Burn
Turn Off
Check Other Burners.
Turn Off Stove Valves
Set Thermostat to Heat
Confirm Furnace Ignition
Confirm Heater Vent Airflow and Temperature
Shut Off Thermostat
Confirm No Leaks from All Stove Valves in the OFF Position

APPLIANCE CHECKS (On Both Shore Power AND Generator/Inverter)
Attach Shore Power (or use Generator)
Check and Clean Air Conditioner Filters
Turn on Air Conditioner, Wait for it to engage
Check for Cool Air
Check for Heat Strip Operation (if installed)
Shutdown Air Conditioner
Inspect Microwave
Set Clock
Run for 1 Minute (heat something up!)
Check Coffee Maker Operation (VERY Important!)
Remove and Store Refrigerator Door Spacer
Inspect And Clean Refrigerator Interior
Check Fridge DC Control Panel Operation
Turn On Refrigerator (on AC Power)
Clean Out Refrigerator Chimney/Fan/Cooling Fins/Tubes and Check for Debris/Nests/Bugs
Confirm Refrigerator Heating Element is Warming Boiler in Outside Compartment)
Switch Refrigerator to Propane (LP Gas)
Confirm Flame Ignition (By Sound AND Visually Outside In Compartment)
Switch Back to Electric (or AUTO)
Check Refrigerator Door Seals and Lock(s)
Replace Refrigerator/Freezer Thermometer Batteries
Turn On Entertainment System
Check Inputs (Antenna/VCR/DVD/Satellite/VGA/HDMI)
Check Bluetooth (If Applicable!)
Check Sound
Raise/Lower TV/Satellite Antenna
Turn Everything Off.

WATER SYSTEM (without Sanitize) 
Re-Connect Water Pump to Tank
Set Valves to Tank Fill
Re-Insert Water Heater Drain Plug
Close Low Point Hot and Cold Water Drains
Check All Fittings
Close Faucets
Partially Fill Water Tank (Hose or Connect City Water)
Set Valves To Operating Position
Turn of Water Heater Bypass (If You Have One!)
Pressurize System (Pump and City Water, One at a time)
Check For Leaks
Open Each Faucet Until It Runs Clear(to Remove Antifreeze and Air)
Check Toilet Main Drain. (Holding Antifreeze?)
Check Flush Fill and Drain
Fill Fresh Water Tank (and/or Use City Water)
Check Faucet Water Filter
Check For Leaks (Look in All Cabinets! Under Coach as Well!)
Open Faucets and Run Water until Clear
Check For Leaks AGAIN!!
Make Sure Water Heater Emergency Pressure Relief Valve is Closed!
Turn On Water Heater (Propane)
Check for Ignition
Wait At Least 10 Minutes (Water Has to Heat Up You know!)
Confirm Hot Water and Flow
Check For Leaks (Inside Hot Side Plumbing AND Outside Water Heater Compartment)
Switch Water Heater to Electric (If You Have It Installed)
Confirm Hot Water and Flow
Clean and Inspect Water Drains and Pipes
Shut Everything Down

LAST
Close All Windows
Shut Off All Appliances
Shut Down Propane Gas Flow
Turn Off Lights
Close and Lock Doors.

While this list is geared toward my coach, most of it will likely apply to yours. Hopefully, it will start you off  safely and with some peace of mind this season.


Feel free to send me new items to add or ask questions!

Be Seeing You....Down The Road

Rich "The Wanderman"
http://www.thewanderman.com

##RVT787


2 comments:

  1. Thanks for that comprehensive list.

    ReplyDelete
    Replies
    1. Karen,
      I am sure I missed items! Every year I add to the list and modify some items. Hopefully, it will save someone so aggravation or worse!

      Rich "The Wanderman"

      Delete

Thank you for your comment. Our moderator checks each one to make sure we keep the Spammers away. So the comment will likely not appear immediately.